Could China Build Aircraft Carriers for Russia?

By Robert Farley,The National Interest

The Russian aircraft carrier Admiral Kuznetsov has entered what is expected to be a substantial refit. Its performance in a recent deployment off Syria was not adequate; in addition to engine problems, it suffered flight-deck issues that contributed to the loss of two fighters, a substantial portion of its flight group. The readiness of Kuznetsov has suffered across its entire career, in large part due to a lack of experience and maintenance funding. As it is already nearly thirty years old, it is unclear how much more service the Russian Navy can wring from the hull.

And yet there is little reason to hope for a replacement on the near horizon. Despite occasional claims that a new carrier will be laid down soon, serious design work has yet to begin. Moreover, in a time of defense austerity, Russia seems to be deemphasizing its surface fleet. It is not at all clear that Russia could build an aircraft carrier in a reasonable time frame even if it wanted to.

But, what if Russia decided to look elsewhere, as more than a few countries have done in the past? What if Russia decided to purchase an aircraft carrier from China?

Recommended:5 Worst Guns Ever Made[3].

Russian Shipbuilding Is a Disaster; Chinese Shipbuilding Is World-Beating

Russian shipbuilding is, at least as far as large surface ships are concerned, a complete mess. In the last decade and a half, Russia has largely reconstituted its ability to build submarines, as well as to construct small surface vessels. This has not, as yet, extended to the construction of large ships. The transfer of two Mistrals from France was intended to jumpstart the industry, as two additional ships would be constructed in Russian yards. However, the deal fell through and no clear plans for replacement have come to fruition. Even the reconstruction of INS Vikramaditya, intended in part to rebuild skills in carrier construction, ended half a decade ago.

The problem is exacerbated by the loss of Ukraine. All four Kiev-class carriers were built in Ukraine, as were the two Kuznetsov-class ships. Ukraine, of course, gained its independence with the dissolution of the Soviet Union, and while relations between the two countries remained cordial enough to continue defense-industrial cooperation until 2014, the annexation of Crimea ended that.

Chinese shipbuilding, on the other hand, has made tremendous strides over the past decade. Since 2007, China has launched six twenty-five-thousand-ton LPDs, seventeen seven-thousand-plus-ton destroyers, one thirteen-thousand-ton cruiser and, of course, a new aircraft carrier. China’s newest carrier, a half-sister to Liaoning and to the Russian Admiral Kuznetsov, will soon enter sea trials, a mere five years after being laid down. A new carrier, of indigenous design and displacing eighty-five thousand tons, has been under construction since 2016. China is also building a large, flat-decked amphibious assault carrier, displacing some forty thousand tons, and six additional cruisers.

In short, China has recent experience building large aviation warships, while Russia has no experience building a surface ship larger than a destroyer since the end of the Cold War.

Past Experience with Capital Ship Acquisition

There is nothing new or unusual about navies acquiring capital ships from foreign builders. During the dreadnought period, countries regularly ordered major vessels for construction from foreign yards; the United States, the UK and Germany each constructed battleships for navies in Europe, Asia and South America. In some cases, this included technology transfer and a kick-start for domestic shipbuilding, as was Japan’s intent in ordering battleships from British yards. In other cases, the buyer had no intention of ever constructing such vessels on its own. The trend continued after World War II, as the United States and the United Kingdom exported aircraft carriers to a variety of countries.

More recently, Russia reconstructed the carrier Baku and transferred it to India, where it became INS Vikramaditya. Ukraine transferred the incomplete hulk of the carrier Varyag to China, which rebuilt the ship and commissioned it as Liaoning. As noted above, Russia itself attempted to purchase a pair of assault carriers from France, seeking technology transfer and an industrial jumpstart. This transfer failed because of Russia’s annexation of Crimea.

Could It Happen?

Analysts are skeptical. According to CNA’s Michael Kofman, “the idea is not entirely crazy, it is simply that there is little discernible need for a carrier in the Russian navy. I don’t see any drive or desire to attain a new carrier in Russia. Russia has no practical need of a carrier, it is simply for symbolic purposes to project status. Its only practical mission is to sustain Russian naval aviation; that part of the service doesn’t want to die so they need a carrier. If the carrier goes then the naval aviation goes. As such the Kuznetsov does fine.”

Dmitry Gorenburg makes a similar case. “The Russian military leadership decided in recent years to focus its naval construction on smaller ships with more powerful armaments, rather than going for recreating the big blue water navy that the Soviet Union developed under Gorshkov. There’s little reason to pour resources into an aircraft carrier when you aren’t even building destroyers. The previous attempt to buy a big ship from a foreign shipyard was very controversial domestically because of opposition both from domestic industry and from traditionalists in the Russian military who did not want to be dependent on a foreign power for military hardware. That past experience will act as a discouraging factor for anyone who might want to try again, even if China is not the same as France from a political point of view.”

Upsides and Downsides

The fact that Russia’s strategic rationale for carrier acquisition is tenuous may actually speak in favor of foreign acquisition. Unlike the United States and (apparently) China, Russia will have no need for the long-term infrastructure needed to maintain a modern carrier fleet. As many countries have done in the past, Russia could even outsource downstream maintenance and refurbishment work to China. And there is no question that China can churn out a carrier faster than Russia can build one, and probably at a higher quality of construction, given the extensive experience of its shipbuilders.

For China, the upsides would also be clear; the construction of a Russian carrier would further the development of infrastructure and human capital necessary to build future carriers. It would help cement the emerging Moscow-Beijing security relationship, and offer deeper insight into the proprietary technologies that Russia might wish to install on the carrier. It would give China greater administrative experience on the international warship-building market.

The only downside for China would be that a Russian carrier would take up space and industrial capacity in Chinese yards, but this is a small price to pay. The downsides for Russia are more palpable; an aircraft carrier purchased from China still costs money, and still re
quires a long-term investment in maintenance and modernization. Russian prestige might also take a hit; as Kofman suggests, “over time Russia will become more comfortable importing Chinese components, but this will take years to overcome pride and stigma. The Russian Navy, like most navies, suffers from its own megalomania and big ship dreams that budgets have to contain.” Gorenburg adds, “the visuals of Russia buying from China vs. selling to China would cement the image shift to junior partner.”

Getting Real

To be sure, there would be many obstacles to overcome. But Russia has made extensive use of Kuznetsov, the lack of a compelling strategic rationale notwithstanding. As the carrier grows older, it will likely become less useful for the prestige cruises that the Kremlin enjoys. Any substantial gap between Kuznetsov and the next Russian carrier (if there is one) would be devastating for training. Even acquiring a ship of the Kuznetsov-Liaoning type, which China can obviously build, would be an improvement for Russia. News of a Russian order from a Chinese yard would be surprising, but not shocking.

This story was originally published by The National Interest

Robert Farley, a frequent contributor to the National Interest*, is author of* The Battleship Book [6]. He serves as a senior lecturer at the Patterson School of Diplomacy and International Commerce at the University of Kentucky. His work includes military doctrine, national security and maritime affairs. He blogs atLawyers, Guns and Money [7],Information Dissemination [8]and theDiplomat [9].

Image [10]: Flickr

More Weapons and Technology – WARRIOR MAVEN (CLICK HERE)
All Scout Warrior content has now moved to www.warriormaven.com

WARRIOR MAVEN’s Premium Offer – Free for US Military – Offers Q&A with US Military Leaders – PREMIUM CLICK HERE

— Kris Osborn, Managing Editor of WARRIOR MAVEN (CLICK HERE) can be reached at krisosborn.ko@gmail.com —

More From Warrior Maven